[1]黄远,韩冰.高强灌浆料与钢筋黏结滑移试验研究[J].地震工程与工程振动,2022,42(02):052-61.[doi:10.13197/j.eeed.2022.0206]
　HUANG Yuan,HAN Bing.Experimental study on bond-slip between high strength grout and steel bar[J].EARTHQUAKE ENGINEERING AND ENGINEERING DYNAMICS,2022,42(02):052-61.[doi:10.13197/j.eeed.2022.0206]
点击复制

高强灌浆料与钢筋黏结滑移试验研究
分享到：

《地震工程与工程振动》[ISSN:/CN:]

卷:
42
期数:
2022年02期
页码:
052-61
栏目:
论文
出版日期:
2022-04-30

文章信息/Info

Title:
Experimental study on bond-slip between high strength grout and steel bar
作者:
黄远1;  韩冰2
1. 湖南大学 工程结构损伤诊断湖南省重点实验室, 湖南 长沙 410082;
2. 湖南大学 土木工程学院, 湖南 长沙 410082
Author(s):
HUANG Yuan1;  HAN Bing2
1. Hunan Provincial Key Lab on Damage Diagnosis for Engineering Structures, Hunan University, Changsha 410082, China;
2. College of Civil Engineering, Hunan University, Changsha 410082, China
关键词:
高强灌浆料; 钢筋连接; 中心拔出; 黏结强度; 峰值滑移
Keywords:
high strength grout; steel bar connections; central pull-out; bond strength; peak slip
分类号:
TU375TU317.1
DOI:
10.13197/j.eeed.2022.0206
摘要:
高强灌浆料被普遍用于装配式混凝土结构节点连接，用以提高钢筋连接的锚固性能。文中采用控制变量法设计了87个中心拔出试件来探究抗压强度、钢筋强度等级、钢筋直径、横向配箍和黏结长度等因素对钢筋－灌浆料黏结性能的影响。结果表明：提高灌浆料的抗压强度（85.8～122.7 MPa）不能提高黏结强度，这区别于以往混凝土拔出试验的研究结论；对于钢筋屈服前拔出和屈服后拔出2种破坏模式试件，提高钢筋强度等级仅对后者的黏结强度有提升作用；增加钢筋直径将降低黏结强度；设置箍筋并改变箍筋密度对拔出破坏试件的黏结强度没有影响；随着黏结长度的增加，黏结强度先增加后减小。通过参数分析提出黏结强度和峰值滑移的计算公式，计算值与试验结果吻合良好。
Abstract:
High strength grout is widely used for joint connection of precast concrete structures to improve the anchorage performance of steel bar connections.In this paper,87 central pull-out specimens were designed using the the control variable method to investigate the effects of compressive strength,reinforcement strength grade,steel bar diameter,transverse stirrups and bond length on the bond performance between high strength grout and steel bar. It is showed that the improving grout compressive strength(85.8~122.7 MPa)cannot enhance the bond strength,which is different from the conclusion of previous concrete pull-out tests.For the two failure modes of pullout before steel yielding and pull-out after yielding,increasing the reinforcement strength grade can only improve the latter specimens’ bond strength.Increasing steel bar diameter decreases the bond strength.Adding stirrups and changing stirrups density have no effect on the bond strength of pull-out specimens.The bond strength increases first and then decreases with the increase of the bond length.The calculation formulas of bond strength and peak slip were put forward through parameter analysis,and the calculated values were in good agreement with the test results.

参考文献/References:

[1] 葛继平,闫兴非,王志强. 机械套筒连接的轨道交通预制拼装桥墩抗震性能试验研究[J]. 地震工程与工程振动,2017,37(6):143-153. GE Jiping,YAN Xingfei,WANG Zhiqiang. Seismic performance analysis of rail transit segmental bridge columns with mechanical splices[J]. Earthquake Engineering and Engineering Dynamics,2017,37(6):143-153.(in Chinese)
[2] 黄远,杨扬,许铭,等. 插筋灌浆连接水平拼缝受剪性能试验研究与有限元分析[J]. 建筑结构学报,2016,37(3):103-109. HUANG Yuan,YANG Yang,XU Ming,et al. Experimental study and finite element analysis on shear performance of horizontal grouted rebar connections[J]. Journal of Building Structures,2016,37(3):103-109.(in Chinese)
[3] 杨扬,黄远,易展辉,等. 插筋灌浆连接装配式钢筋混凝土剪力墙抗侧承载力分析[J]. 地震工程与工程振动,2016,36(6):180-187. YANG Yang,HUANG Yuan,YI Zhanhui,et al. Lateral force resistant capacity of precast concrete shear wall with horizontal seam[J]. Earthquake Engineering and Engineering Dynamics,2016,36(6):180-187.(in Chinese)
[4] 易伟建,余东,江涛. HRB500级钢筋混凝土框架梁开裂性能试验研究[J]. 建筑结构学报,2013,34(1):147-154. YI Weijian,YU Dong,JIANG Tao. Experimental research on cracks of HRB500 steel reinforced concrete frame beams[J]. Journal of Building Structures,2013,34(1):147-154.(in Chinese)
[5] 郭子雄,周素琴. RC框架节点的弯矩-滑移转角恢复力模型[J]. 地震工程与工程振动,2003,23(1):118-124. GUO Zixiong,ZHOU Suqin. A hysteretic model for simulating moment-anchorage slip-rotation relationship of RC frame structure[J]. Earthquake Engineering and Engineering Dynamics,2003,23(1):118-124.(in Chinese)
[6] 吴曦,汪梦甫. 预制叠合剪力墙新型连接节点抗震性能研究[J]. 地震工程与工程振动,2019,39(4):73-85. WU Xi,WANG Mengfu. Study on the seismic performance of precast composite shear walls with innovate connection joints[J]. Earthquake Engineering and Engineering Dynamics,2019,39(4):73-85.(in Chinese)
[7] BUTLER L J,WEST J S,TIGHE S L. Bond of reinforcement in concrete incorporating recycled concrete aggregates[J]. Journal of Structure Engineering-ASCE,2015,141(3):B4014001.
[8] HOSSEINI S J A,RAHMAN A B A,OSMAN M H,et al. Bond behavior of spirally confined splice of deformed bars in grout[J]. Construction and Building Materials,2015,80:180-194.
[9] RAYNOR D J,LEHMAN D E,STANTON J F. Bond-slip response of reinforcing bars grouted in ducts[J]. ACI Structural Journal,2002,99(5):568-576.
[10] ELSAYED M,NEHDI M L,PROVOST-SMITH D J,et al. Exploratory investigation of grouted bar-in-duct connections under direct tensile load[J]. Construction and Building Materials,2018,183:311-324.
[11] MOOSAVI M,JAFARI A,KHOSRAVI A. Bond of cement grouted reinforcing bars under constant radial pressure[J]. Cement and Concrete Composites,2005,27(1):103-109.
[12] 赵培. 约束浆锚钢筋搭接连接试验研究[D]. 哈尔滨:哈尔滨工业大学,2011:31-49. ZHAO Pei,Experimental Research on Restraint Grouting-anchorage Overlap-joint of Steel Bar[D]. Harbin:Harbin Institute of Technology, 2011:31-49.(in Chinese)
[13] 陈俊,肖岩,尹齐. 预埋波纹套管的钢筋-高强浇筑料黏结锚固性能试验研究[J]. 建筑结构学报,2015,36(7):140-147. CHEN Jun,XIAO Yan,YIN Qi. Bonding strength of rebar anchorage in embedded corrugated sleeve with high strength grout[J]. Journal of Building Structures,2015,36(7):140-147.(in Chinese)
[14] 余琼,许雪静,尤高帅. 带肋钢筋与灌浆料黏结性能试验[J]. 哈尔滨工业大学学报,2017,49(12):91-101.YU Qiong,XU Xuejing,YOU Gaoshuai. Experimental study on bond behavior for ribbed steel bars and grout[J]. Journal of Harbin Institute of Technology,2017,49(12):91-101.(in Chinese)
[15] JGJ 1-2014装配式混凝土结构技术规程[S]. 北京:中国建筑工业出版社,2014. JGJ 1-2014 Technical Specification for Precast Concrete Structures[S]. Beijing:China Architecture & Building Press,2014.(in Chinese)
[16] GB/T 17671-1999水泥胶砂强度检验方法(ISO法)[S]. 北京:中国标准出版社,1999. GB/T 17671-1999 Method of Testing Cements-Determination of Strength[S]. Beijing:China Architecture & Building Press,1999.(In Chinese)
[17] SOLEYMANIASHTIANI M,DHAKAL R P,SCOTT A N. Post-yield bond behaviour of deformed bars in high-strength self-compacting concrete[J]. Construction and Building Materials,2013,44:236-248.
[18] 徐有邻. 变形钢筋-混凝土黏结锚固性能的试验研究[D]. 北京:清华大学,1990:49-58. XU Youlin. Experimental Study of Anchorage Properties for Deformed Bars in Concrete[D]. Beijing:Tsinghua University,1990:49-58.(in Chinese)
[19] 庄金平,郑建岚. 自密实混凝土与钢筋局部黏结性能试验研究[J]. 建筑结构学报,2013,34(6):143-152. ZHUANG Jinping,ZHENG Jianlan. Experiment research on local bond performance between reinforcement and self-compacting concrete[J]. Journal of Building Structures,2013,34(6):143-152.(in Chinese)
[20] 邓明科,潘姣姣,梁兴文. 高延性混凝土与钢筋黏结性能的试验研究[J]. 土木工程学报,2018,51(3):19-26. DENG Mingke,PAN Jiaojiao,LIANG Xingwen. Experimental study on bond behavior between steel bar and high ductility concrete[J]. China Civil Engineering Journal,2018,51(3):19-26.(In Chinese)
[21] ICHINOSE T,KANAYAMA Y,INOUE Y,et al. Size effect on bond strength of deformed bars[J]. Construction and Building Materials,2004,18(7):549-558.
[22] METELLI G,PLIZZARI G A. Influence of the relative rib area on bond behaviour[J]. Magazine of Concrete Research,2014,66(6):277-294.

备注/Memo

备注/Memo:
收稿日期:2021-4-15;改回日期:2021-5-21。
基金项目:国家自然科学基金项目（51890901）；湖南省自然科学基金项目（2020JJ2003）
作者简介:黄远(1982-),男,教授,博士,主要从事装配式混凝土结构、钢-混凝土组合结构和结构抗震分析方面的研究.E-mail:huangy@hnu.edu.cn
更新日期/Last Update: 1900-01-01